VW Bora TDI 1.9 ALH with mods, Rate My Tune

Help and tips about your tune, post your work in here.

Re: VW Bora TDI 1.9 ALH with mods, Rate My Tune

Postby juice » Wed Sep 24, 2014 7:53 pm

Put 2200 mbar its okay. You are righabout n146, you should copy asv map only if change pump plunger from 10mm with 11mm the actually plunger from ASV. Well just changed nozzles its okay to keep voltage map stock. Put 2200 mbar and its fine, check also for smoke to dont have too high EGT and damage turbo.

juice
Diamond
 
Posts: 422
Joined: Sat Oct 05, 2013 5:28 pm
Location: Romania

Re: VW Bora TDI 1.9 ALH with mods, Rate My Tune

Postby Enabled » Thu Sep 25, 2014 4:22 pm

Understood. Will be bringing it up to 2200 mbar.

Now, one more question. Which limiting map is responsible for telling the car to go into limp mode due to a boost spike? SVBL or the boost pressure limiter (atmospheric)?

Reason I ask is that I again got a limp mode due to overboost at around 160km/h (don't ask) and about 3000 RPM (I have a lower 5th gear ratio installed).

I usually get a boost spike to about 1500mbar (2500mbar absolute pressure) on full throttle, and then it settles around 2152mbar (absolute pressure) sustained. Not at all bad for the turbo, so I think my N75 map is behaving correctly. I should have about +50mbar difference in the limiter maps compared to requested boost?

Enabled
New user
 
Posts: 22
Joined: Mon Sep 22, 2014 1:58 am

Re: VW Bora TDI 1.9 ALH with mods, Rate My Tune

Postby Enabled » Thu Sep 25, 2014 4:53 pm

I raised my X-axis description on N75 last column from 45 IQ to 50 IQ for better control at my max fueling (50mg), and the peak N75 maps have been raised by about 8%, but I can go up to 10% if needed. Will continue to monitor with VCDS.





Another topic:

If I do Mass Air Flow logging in g/sec at wide open throttle... the following calculation should give me the estimated air quantity at a certain RPM (intake + boosted air; my EGR air intake is turned off so no other air source):

(g/s) x60 = g/min
(g/min) x1000 = mg/min
(mg/min) / RPM = mg/revolution
(mg/rev) / 2 (because there are 2 strokes per revolution) = mg/stroke

Enabled
New user
 
Posts: 22
Joined: Mon Sep 22, 2014 1:58 am

Re: VW Bora TDI 1.9 ALH with mods, Rate My Tune

Postby juice » Thu Sep 25, 2014 5:13 pm

SVBL is responsible for limp mode. The maximum deviation is 300 or 400 mbar, well if you have 2250 maximum limit svbl(put it 2250), and you measure 2550 2600 its bad and risky. Increase last column with 10 to 15% dont worry about loosing power, PID controller will close a bit vanes if need to achieve pressure. If still overboost, then you have sticky vanes or weak actuator spring.

juice
Diamond
 
Posts: 422
Joined: Sat Oct 05, 2013 5:28 pm
Location: Romania

Re: VW Bora TDI 1.9 ALH with mods, Rate My Tune

Postby Enabled » Thu Sep 25, 2014 5:56 pm

juice wrote:SVBL is responsible for limp mode. The maximum deviation is 300 or 400 mbar, well if you have 2250 maximum limit svbl(put it 2250), and you measure 2550 2600 its bad and risky. Increase last column with 10 to 15% dont worry about loosing power, PID controller will close a bit vanes if need to achieve pressure. If still overboost, then you have sticky vanes or weak actuator spring.


Ok, great. Excellent info. I was afraid I'd be losing power if I raise N75 even more.

My vanes should be clean, as I've chemically cleaned the turbo twice, and before the tune, I got no more limp modes for many months. I'll check vacuum system as well.
So far I'm very happy with the tune. Thank you for all the feedback, I learned a bunch. Hope it's a good learning experience for others watching.

Enabled
New user
 
Posts: 22
Joined: Mon Sep 22, 2014 1:58 am

Re: VW Bora TDI 1.9 ALH with mods, Rate My Tune

Postby juice » Thu Sep 25, 2014 6:26 pm

You will not loose power until you open vanes too much, maybe the little 10mm nut is adjusted for too closed position. Better lower power than fucked turbo. I can tell you that several overboots to 2400 2500 will blow instantly that little ALH turbo when you want to overtake some cars.

juice
Diamond
 
Posts: 422
Joined: Sat Oct 05, 2013 5:28 pm
Location: Romania

Re: VW Bora TDI 1.9 ALH with mods, Rate My Tune

Postby Enabled » Sun Oct 12, 2014 5:42 am

If I wanted to install a 3bar MAP sensor (instead of the 2.5bar one), where would I find MAP Sensor (manifold air pressure) maps in my EDC15? Or what do they usually look like? VAGEDCSuite doesn't automatically have them, and I'm not sure where to look yet.

Enabled
New user
 
Posts: 22
Joined: Mon Sep 22, 2014 1:58 am

Re: VW Bora TDI 1.9 ALH with mods, Rate My Tune

Postby Enabled » Sun Oct 12, 2014 6:11 am

OK, it seems I have answered my own question just now.

Address = 0749F0 (16 bit)
989 2600
82 200



And should change to something like:
989 3120
82 200


OR (from PD130 engine)

951 3000
82 200

Enabled
New user
 
Posts: 22
Joined: Mon Sep 22, 2014 1:58 am

Re: VW Bora TDI 1.9 ALH with mods, Rate My Tune

Postby starnet » Mon Dec 28, 2015 12:19 am

I have a bora 110ps but AHF
my plan to change the entire installation and the ecu .
is your ECU edc15vm + ?
so that a know what i need .

tnx :D

starnet
New user
 
Posts: 3
Joined: Sun Dec 27, 2015 9:52 pm
Location: Zagreb Croatia

Previous

Return to Rate My Tune

Who is online

Users browsing this forum: No registered users and 4 guests